[1]陈正发,陈振飞,刘健鹏,等.碳纳米管改性黏土力学性能及微观机制研究[J].郑州大学学报(工学版),2022,43(04):86-91.[doi:10.13705/j.issn.1671-6833.2022.04.012]
　CHEN Zhengfa,CHEN Zhenfei,LIU Jianpeng,et al.Experimental Study on Mechanical Properties and Micro-mechanism of Clay Modified by Carbon Nanotubes[J].Journal of Zhengzhou University (Engineering Science),2022,43(04):86-91.[doi:10.13705/j.issn.1671-6833.2022.04.012]
点击复制

碳纳米管改性黏土力学性能及微观机制研究()
分享到：

《郑州大学学报(工学版)》[ISSN:1671-6833/CN:41-1339/T]

卷:
43
期数:
2022年04期
页码:
86-91
栏目:
出版日期:
2022-07-03

文章信息/Info

Title:
Experimental Study on Mechanical Properties and Micro-mechanism of Clay Modified by Carbon Nanotubes
作者:
陈正发1 ;  陈振飞1;  刘健鹏1;  刘桂凤1 ;  李 岩2
1.常州大学环境与安全工程学院;2.山东大展纳米材料有限公司;

Author(s):
CHEN Zhengfa1; CHEN Zhenfei1; LIU Jianpeng1; LIU Guifeng1; LI Yan2
1.School of Environmental and Safety Engineering，Changzhou Univesity，Changzhou 213164，China;
2.Shandong Dazhan Nanomaterials Co.,Ltd.,Binzhou 256600,China
关键词:
Keywords:
multi-walled carbon nanotubes; clay; soil modification; shear strength; microcosmic mechanism
分类号:
TU521. 3
DOI:
10.13705/j.issn.1671-6833.2022.04.012
文献标志码:
A
摘要:
研究多壁碳纳米管( MWCNTs) 改性黏土力学性能,旨在将其应用于垃圾填埋场衬垫材料的设计和施工中。 通过三轴压缩试验和扫描电子显微镜( SEM) 试验,分析了不同 MWCNTs 掺量( 质量分数,下同) 对黏土抗剪强度的影响规律,并从微观结构演化规律方面揭示了宏观力学特性变化机理。 三轴试验结果表明,抗剪强度随 MWCNTs 掺量增加, 表现为先增加后减小,0. 5% MWCNTs 掺量抗剪强度值最大,且掺加多壁碳纳米管试样的抗剪强度均大于未掺入试样;随 MWCNTs 掺量增加,黏聚力的发展规律与抗剪强度一致,最大值出现在 0. 5% ~ 1. 0% ;内摩擦角则随 MWCNTs 掺量增加表现为先减小后增大, 在 1% 左右 MWCNTs 掺量处最小。 掺入 0. 5% ~ 1. 0% 的 MWCNTs 可以有效提高黏土的抗剪强度。 掺加MWCNTs 改变土体微观结构是引起其宏观力学特性变化的根本原因。 分析 SEM 结果表明,无 MWCNTs 掺量的试样中黏土颗粒间接触较为紧密,大、小孔隙分布较为均匀;掺入 MWCNTs 之后,土样孔隙的数量和尺寸均发生了明显改变。 掺量较低时( 0. 5% ) ,MWCNTs 附着在土颗粒表面,填充孔隙使得孔隙尺寸减小,增加了土样的密实性,从而使得抗剪强度增大;随着 MWCNTs 掺量增加( 1% 和 2% ) 可以观察到试样孔隙数量增多,但均少于无 MWCNTs 掺量试样中的孔隙数量,这种现象归因于 MWCNTs 自身的润滑作用减弱了其对黏土颗粒的吸附胶结作用,导致抗剪强度减小。
Abstract:
Studying the influence of multi-walled carbon nanotubes (MWCNTs) contents on mechanical properties of modified saturated clay is of great significance for its design and application in refuse landfill clay liner materials.Triaxial compression tests and scanning electron microscope (SEM) tests were performed to analyze the influence of different MWCNTs contents on the shear strength and the mechanism of mechanical properties was revealed from the microstructure evolution.The triaxial tests results showed that the shear strength increased first and then decreased with the increasing MWCNTs content,and the maximum value was detected at 0.5% MWCNTs content.The shear strength of samples doped with MWCNTs was greater than that without content.The cohesion strength showed similar change tend with the shear strength and the maximum value existed between 0.5% and 1.0%.The internal friction angle first decreased and then increased with the increasing MWCNTs content,and the minimum value appeared at 1.0% content.The results indicated that the shear strength of clay could be significantly improved by mixing MWCNTs with 0.5%-1.0% content.The MWCNTs altered the microstructure of the clay,which was the main cause of the change in the soil macroscopic mechanical properties.SEM results indicated that the contact between clay particles was relatively close and the large and small pores showed a uniform distribution in the specimen without MWCNTs content.The number and size of pores in the soil sample changed significantly after adding MWCNTs.It increased the compactness of the specimen with lower content,in which the threshold was determined to be 0.5% content,leading to the increase in shear strength.It could be observed that the number of pores increased but was less than the specimen without content with the increasing MWCNTs contents (1% and 2%).It could be attributed to the reason that the adsorption and cementation of MWCNTs on soil particles were weakened due to lubricating effect,resulting in a decrease in shear strength.

参考文献/References:

[1] IIJIMA S. Helical microtubules of graphitic carbon [ J] . Nature, 1991, 354(6348) : 56-58.

 [2] CHITTOO B S, SUTHERLAND C. Use of lime-iron sludge for soil modification [ J] . International journal of material sciences, 2013, 3(2) : 39-44. 
[3] 温亚楠, 朱鸿鹄, 施斌. 纳米膨润土加固黏土强度 的试验研究[ J] . 地下空间与工程学报, 2016, 12 (增刊 1) : 39-43, 48. 
WEN Y N, ZHU H H, SHI B. Experimental study on improving clay strength using nano-bentonite[ J] . Chinese journal of underground space and engineering, 2016, 12( S1) : 39-43, 48.
 [4] BAHMANI S H, HUAT B B K, ASADI A, et al. Stabilization of residual soil using SiO2 nanoparticles and cement [ J ] . Construction and building materials, 2014, 64: 350-359. 
[5] 董祎挈, 陆海军. 污泥灰改性黏土胀缩与开裂变形 特性[ J] . 大连理工大学学报, 2015, 55( 3) : 312 -318. 
DONG Y Q, LU H J. Swelling, shrinking and cracking properties of modified clay containing sewage sludge ash[ J] . Journal of Dalian university of technology, 2015, 55(3) : 312-318. 
[6] 任真, 余湘娟, 高磊. 纳米氧化镁改性黏土强度特 性试验[ J] . 水利水运工程学报, 2016(5) : 85-90. 
REN Z, YU X J, GAO L. Experimental research on strength characteristics of nano-MgO modified soil[ J] . Hydro-science and engineering, 2016(5) : 85-90.
[7] WANG J W, LI H P, SONG L, et al. Effect of cryostructures on the uniaxial compressive strength of frozen clay[ J] . Sciences in cold and arid regions, 2017, 9(3) : 267-272. 
[8] 陈学军, 李家成, 宋宇, 等. 纳米石墨粉对红黏土 力学性 质 的 影 响 [ J ] . 工 程 地 质 学 报, 2018, 26 (1) : 97-102. 
CHEN X J, LI J C, SONG Y, et al. Effect of nano graphite powder on mechanical properties of red clay [ J] . Journal of engineering geology, 2018, 26 ( 1) : 97-102.
 [9] BUDIHARDJO M A, HADIWIDODO M, WARDHANA I W, et al. A study on desiccation cracking behavior of landfill liner developed from construction waste [ J] . IOP conference series: earth and environmental science, 2021, 802(1) : 012004.
 [10] 武雷杰, 杨秀娟, 张路, 等. 聚合氯化铝( PAC) 改 性膨胀土的胀缩特性试验研究[ J] . 长江科学院院 报, 2020, 37(1) : 84-89.
 WU L J, YANG X J, ZHANG L, et al. Experimental study on swelling and shrinkage of polyaluminum chloride ( PAC) modified expansive soil [ J] . Journal of Yangtze River scientific research institute, 2020, 37 (1) : 84-89. 
[11] 祝学勇, 刘海威, 马晓燕, 等. 黄泛区湖淤积高液 限黏土的改性研究[ J] . 山东大学学报( 工学版) , 2019, 49(1) : 83-90, 113. 
ZHU X Y, LIU H W, MA X Y, et al. Study on modification of lake deposition high liquid limit clay in the Yellow River flood area[ J] . Journal of Shandong university ( engineering science) , 2019, 49(1) : 83-90, 113. 
[12] GAO L, LUO Y, REN Z, et al. Experimental study on dynamic properties of nano-MgO-modified silty clay [ J] . International journal of geosynthetics and ground engineering, 2020, 6(2) : 1-9.
 [13] 陆海军, 陈威, 董祎挈. 秸秆纤维黏土混合料作为 填埋场衬垫材料可行性研究[ J] . 大连理工大学学 报, 2014, 54(3) : 323-328. 
LU H J, CHEN W, DONG Y Q. Feasibility study of clay containing straw fiber as landfill liner material [ J] . Journal of Dalian university of technology, 2014, 54(3) : 323-328. 
[14] 白汉营, 高宇豪, 陈学军, 等. 纳米石墨粉红黏土 改良机理试验研究[ J] . 水文地质工程地质, 2018, 45(3) : 86-92. 
BAI H Y, GAO Y H, CHEN X J, et al. An experimental study of the improving mechanical properties of the nano graphite powder red clay [ J] . Hydrogeology & engineering geology, 2018, 45(3) : 86-92. 
[15] GABIDULLIN M G, RAKHIMOV R Z, HUZIN A F, et al. Control of cement stone structure formation by multi-walled carbon nanotubes[C] / / The 14th International Congress on the Chemistry of Cement. Beijing: ICCC, 2015:199-199. 
[16] MOHSEN M O, ALANSARI M, TAHA R, et al. Impact of CNTs′ treatment, length and weight fraction on ordinary concrete mechanical properties[ J] . Construction and building materials, 2020, 264: 120698. 
[17] 郭李娜, 张永波, 段清, 等. 纳米材料改性土壤力 学性质的研究综述 [ J] . 节 水 灌 溉, 2021 ( 3) : 79 -84. 
GUO L N, ZHANG Y B, DUAN Q, et al. A review of the research on mechanical properties of modified soil by nanomaterials [ J ] . Water saving irrigation, 2021 (3) : 79-84.
 [18] 中华人民共和国住房和城乡建设部. 土工试验方 法标准: GB / T 50123—2019[ S] . 北京: 中国计划 出版社,2019. 
Ministry of Housing and Urban-Rural Development of the People′s Republic of China. Standard for geotechnical testing method: GB / T 50123—2019 [ S] . Beijing: China Planning Press, 2019.

更新日期/Last Update: 2022-07-03