[1]周俊杰,王璞,周金方.基于ANSYS CFX的汽轮机叶片气动性能优化模拟研究[J].郑州大学学报(工学版),2017,38(04):1-6.[doi:10.13705/j.issn.1671-6833.2017.01.008]
　Zhou Junjie,Wang Pu,Zhou Jinfang.Study on Numerical Simulation of The Steam Turbine Blade Aerodynamic steam turbine increases.Performance Optimization Based on ANSYS CFX[J].Journal of Zhengzhou University (Engineering Science),2017,38(04):1-6.[doi:10.13705/j.issn.1671-6833.2017.01.008]
点击复制

基于ANSYS CFX的汽轮机叶片气动性能优化模拟研究()
分享到：

《郑州大学学报(工学版)》[ISSN:1671-6833/CN:41-1339/T]

卷:
38卷
期数:
2017年04期
页码:
1-6
栏目:
出版日期:
2017-07-18

文章信息/Info

Title:
Study on Numerical Simulation of The Steam Turbine Blade Aerodynamic steam turbine increases.Performance Optimization Based on ANSYS CFX
作者:
周俊杰; 王璞; 周金方
郑州大学化工与能源学院,河南郑州,450001
Author(s):
Zhou Junjie;  Wang Pu;  Zhou Jinfang
College of Chemical Engineering and Energy, Zhengzhou University, Zhengzhou, Henan 450001
关键词:
汽轮机; 叶片; ANSYS CFX; 数值模拟; 气动性能
Keywords:
DOI:
10.13705/j.issn.1671-6833.2017.01.008
文献标志码:
A
摘要:
以125 MW轴流式汽轮机某一冲动级叶片为研究对象,利用商业软件ANSYS CFX对该级静动叶片的气动性能进行了三维数值模拟优化计算.结果表明,通过优化前缘和尾缘椭圆率、相对节距以及其级间配比等几何参数,降低了表面压力差分布,有效控制了二次流损失;叶片等熵效率提高了0.43％,总压损失系数降低了0.005左右.优化改进后,叶片的气动性能得到提高,降低了其能量损失,增加了汽轮机效率.
Abstract:
The analysis was held with the 125MW axial flow steam turbine impulse stage blade.The three-dimensional numerical simulation and optimization were conducted by using the commercial software ANSYS CFX.The results showed that the pressure distribution of blade surface reduced,and the radial secondary flow loses was controlled effectively,with optimizing the structure geometric parameters such as ellipticity of the leading edge and trailing edge,relative pitch,inter-stage ratio,and so on.Isentropic efficiency increased by 0.43％,the total pressure loss coefficiency decreased about 0.005.After the optimization,the aerodynamic performance of the blade increased,and the energy loss in the blade decreased and the efficiency of steam turbine increased.

相似文献/References:

[1]王定标,雷风林,向飒,等.汽轮机末级变工况三维数值模拟与叶型改进设计[J].郑州大学学报(工学版),2010,31(05):1.[doi:10.3969/j.issn.1671-6833.2010.05.001]
[2]许德刚,翟萍,秦力一..汽轮机的转子损伤与优化启动[J].郑州大学学报(工学版),2002,23(04):1.[doi:10.3969/j.issn.1671-6833.2002.04.001]
　Xu Degang,Zhai Ping,Qin Liyi.Rotor damage and optimized start of steam turbines[J].Journal of Zhengzhou University (Engineering Science),2002,23(04):1.[doi:10.3969/j.issn.1671-6833.2002.04.001]
[3]陈静波.叶片失调阶次及离心力效应对叶栅颤振边界的影响[J].郑州大学学报(工学版),1990,11(03):107.
　Chen Jingbo,The impact of leaves of leaves and centrifugal effects on the border of the leaves of the leaves of the leaves[J].Journal of Zhengzhou University (Engineering Science),1990,11(04):107.

更新日期/Last Update: